Does the automobile turbocharger Cartridge need to be replaced?
Does the automobile turbocharger Cartridge need to be replaced?
The automobile turbocharger cartridge is not a vulnerable part, and there is no fixed replacement time; Only when the turbocharger is broken and cannot be repaired, it needs to be replaced. When it is good, it does not need to be replaced. When the turbocharger is broken, the engine power is insufficient, the noise is too large, the fuel consumption is thickened, and the exhaust emission is not up to standard.
Proper maintenance can greatly prolong the service life of the turbocharger cartridge. In order to prolong the service life of turbocharger, the following three points should be paid attention to:
1: In the process of vehicle driving, the temperature produced by turbocharger is high, and its mechanical structure is relatively special, so there are special requirements for the selection of oil. The oil used in daily maintenance of general models usually cannot meet the requirements of turbocharged models. Therefore, high-quality synthetic engine oil or special engine oil for turbocharged vehicles must be used in the maintenance process. The quality grade of engine oil should not be lower than the level recommended in the vehicle manual. At the same time, the engine oil should be changed periodically to prevent the engine oil from deteriorating and causing losses.
2: After starting the engine, especially in the cold season, it is necessary to idle for a period of time to fully lubricate the bearing of the turbocharger Rotor before high-speed operation. Don't bang the accelerator violently after starting the car to prevent damaging the turbocharger oil seal. After the car is driven for a long time and under heavy load, the engine should be idled for 3-5 minutes before stalling, so that the speed of the turbocharger rotor can be reduced before stalling. Don't suddenly shut down after suddenly stepping on the accelerator.
3: During daily driving on urban roads, due to insufficient speed, the turbocharger system with "t" car often does not play a great role, and long-term traffic jam may lead to carbon deposition. Excessive carbon deposition is easy to affect the engine cosmetic work, and will also harm the turbocharging system. Therefore, it is recommended that car owners remove carbon deposits during maintenance during the driving mileage of 20000-30000 km.
